Golf cart battery maintenance method:
1. If the battery is not used for a long time, it will slowly discharge itself until it is scrapped. Therefore, the golf cart should be started at regular intervals to charge the battery.
2. When the ammeter pointer shows that the storage capacity is insufficient, charge it in time. The storage capacity of the battery can be reflected on the instrument panel. Sometimes it is found that the power is not enough on the road, and the engine is turned off and cannot be started. As a temporary measure, you can ask other vehicles for help, use the batteries on their vehicles to start the vehicle, and connect the negative poles of the two batteries to the negative poles, and the positive poles to the positive poles.
3. The density of the electrolyte should be adjusted according to the standards in different regions and seasons.
4. Distilled water or special rehydration fluid should be supplemented when the electrolyte is depleted. Do not use pure drinking water instead. Because pure water contains a variety of trace elements, it will cause adverse effects on the battery.
5. During daily driving, you should always check whether the small hole on the battery cover is ventilated. If the small hole of the battery cover is blocked, the generated hydrogen and oxygen cannot be discharged, and when the electrolyte expands, the battery casing will be broken, affecting the life of the battery.
6. Use a special charger when charging, place it in a cool and ventilated place, and avoid high temperature and humidity
7. Do not use organic solvents to clean the battery case
8. Do not short-circuit the positive and negative terminals of the battery to avoid danger
9. Prohibition of over-discharge: When the red Undervoltage indicator light on the instrument panel glows, it indicates that the power has entered the starvation zone and should be charged in time
10. Prohibition of overcharging: The charging time should be different according to the length of the driving mileage. The longer the mileage, the longer the charging time, and vice versa.
11. If the battery pack fails, please send it to the authorized officer of the manufacturer or relevant institutions for proper disposal. Please do not discard at will to avoid environmental pollution
Troubleshooting methods for golf cart batteries:
Battery failure when shifting gears: For a golf cart that has traveled 1,500 kilometers and needs to shift to 1st gear due to special circumstances during driving, the battery light of the golf cart will be on, but it will go out immediately, and the car is still normal. When encountering this situation, one of the reasons is that the engine has greatly fluctuated, and the battery has been disconnected, which may cause this situation in an instant. It is recommended to check the battery connection of the car first. Loss of speed fault, a Gower car with a mileage of 15200km, when driving at a medium speed (vehicle speed 80km/h, engine speed 2000rpm), the phenomenon of engine speed loss (the speed drops by about 200rpm) occurs. Sometimes it's a split second, sometimes it's a little longer, and then the engine goes back to normal. There is no regularity in the time interval of the loss of speed fault. After overhaul, the failure is due to the poor connection between the ground wire of the engine electronic control unit and the negative pole of the golf cart battery, resulting in an occasional failure caused by the instantaneous control failure of the engine computer. Because of this fault, the engine computer will have an instantaneous fuel injection control failure at medium speed, so that the concentration of the mixture gas does not meet the requirements, resulting in a drop in power. It is necessary to go to the maintenance station to repair the connection between the ground wire of the engine electronic control unit and the negative pole of the golf cart battery. Handling and cleaning.
Guangzhou Izonword Electric Vehicle Co., Ltd. is a sizable golf cart manufacturer in China, The company was founded in 2009, and our 60,000 sqm plant in Guangzhou has more than 300 employees and 4 production lines, with an in-house chassis frame manufacturing workshop.
